Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 HERSCHER RESTAURANT & PUB 		License/Permit #
 HE022
Street Address
171 S MAIN ST
City/State
 HERSCHER, IL 		ZIP Code
 60941
No. of Risk Factor/Intervention Violations 2
No. of Repeat Risk Factor/Intervention Violations 0
Date 10/06/2023
Time In 09:40 AM
Time Out 12:30 PM
Permit Holder
DZABIRI, SADET 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39 X Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41 X Wiping cloths: properly used & stored X  
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43 X In-use utensils: properly stored X  
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: HERSCHER RESTAURANT & PUB Establishment #: HE022
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: 0 - 50 (CHLORINE) Heat: N/A (CHLORINE 50) °F
CFPM Verification (name, ID#, expiration date):
FRANCISCO GARCIA
22657722
09/14/2027 		SEADET DZABIRI
25439977
03/06/2029 		ERDOGAN KURAP
25365922
03/12/2029 		DENISE MAYBURY
22719160
09/27/2027

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
/grista stand-up freezer - main prep line -1.00°F cut tomatoes; pineapple/reach-in cooler/prep-table at main cook line 39.00°F marinara sauce; pork; sausage gravy; soup/warming table at main cook line 160.00°F
fish/true cooler at main cook line 39.00°F ground beef/cooked in pot on stove 180.00°F soup /reheated in warmer 175.00°F
taco meat; shaved gyro meat/walk-in cooler 39.00°F /chest freezer near dish washer -1.00°F /pizza station chest freezer -1.00°F
mushrooms/beer/pizza walk-in cooler 41.00°F tomatos sauce, diced onions/pizza prep cooler 37.00°F /server station chest freezer -1.00°F
soup/portable warmer at server station 165.00°F cut cucumbers /reach-in cooler/prep-table at server's station 39.00°F  

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
23 PF 3-501.17 (A-B) (E-G): (A)Except when PACKAGING FOOD using a REDUCED OXYGEN PACKAGING method as specified under § 3-502.12, and except as specified in ¶¶ (E) and (F) of this section, refrigerated, READY-TO -EAT, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and held in a FOOD ESTABLISHMENT for more than 24 hours shall be clearly marked to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded when held at a temperature of 5ºC (41ºF) or less for a maximum of 7 days. The day of preparation shall be counted as Day 1. (B) Except as specified in ¶¶ (E) - (G) of this section, refrigerated, READY-TO-EAT TIME/TEMPERATURE CONTROL FOR SAFETY FOOD prepared and PACKAGED by a FOOD PROCESSING PLANT shall be clearly marked, at the time the original container is opened in a FOOD ESTABLISHMENT and if the FOOD is held for more than 24 hours, to indicate the date or day by which the FOOD shall be consumed on the PREMISES, sold, or discarded, based on the temperature and time combinations specified in ¶ (A) of this section and: (1) The day the original container is opened in the FOOD ESTABLISHMENT shall be counted as Day 1; and (2) The day or date marked by the FOOD ESTABLISHMENT may not exceed a manufacturer’s use-by date if the manufacturer determined the use-by date based on FOOD safety. (E) Paragraphs (A) and (B) of this section do not apply to individual meal portions served or rePACKAGED for sale from a bulk container upon a consumer’s request. (F) Paragraphs (A) and (B) of this section do not apply to SHELLSTOCK.  (G) Paragraph (B) of this section does not apply to the following FOODS prepared and PACKAGED by a FOOD PROCESSING PLANT inspected by a REGULATORY AUTHORITY: (1) Deli salads, such as ham salad, seafood salad, chicken salad, egg salad, pasta salad, potato salad, and macaroni salad, manufactured in accordance with 21 CFR 110 Current good manufacturing practice in manufacturing, packing, or holding human food; (2) Hard cheeses containing not more than 39% moisture as defined in 21 CFR 133 Cheeses and related cheese products, such as cheddar, gruyere, parmesan and reggiano, and romano; (3) Semi-soft cheeses containing more than 39% moisture, but not more than 50% moisture, as defined in 21 CFR 133 cheeses and related cheese products, such as blue, edam, gorgonzola, gouda, and monterey jack; (4) Cultured dairy products as defined in 21 CFR 131 Milk and cream, such as yogurt, sour cream, and buttermilk; (5) Preserved FISH products, such as pickled herring and dried or salted cod, and other acidified FISH products defined in 21 CFR 114 Acidified foods; (6) Shelf stable, dry fermented sausages, such as pepperoni and Genoa; and (7) Shelf stable salt-cured products such as prosciutto and Parma (ham).
violation: within the walk-in cooler, prepped food items that have been stored for more that 24 hours have not been labeled. corrective action required: labeled all prepped food items with a 'discard' or 'use-by' date. - (Correct By: Oct 16, 2023)
28 PF 7-102.11: Working containers used for storing POISONOUS OR TOXIC MATERIALS such as cleaners and SANITIZERS taken from bulk supplies shall be clearly and individually identified with the common name of the material.
violation: a red chemical stored in a spray bottle located near the 3-compartment sink is not labeled. corrective action: label storage container with the common name of the chemical. - (Correct By: Oct 16, 2023)
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
violation: several food items stored within the walk-in cooler are not properly covered, including: (1) two containers of skinned potatoes, (2) cut onions, (3) and raw chicken. corrective action required: cover all food containers by the next routine inspection.
41 C 3-304.14 (B)(1)(2): (B) Cloths in-use for wiping counters and other EQUIPMENT surfaces shall be: (1) Held between uses in a chemical sanitizer solution at a concentration specified under § 4-501.114; and (2) Laundered daily as specified under ¶ 4-802.11(D).
violation: wiping cloths were found stored on prep counters at the main cook line. corrective action taken: wiping cloths were placed in sanitizer bucket. COS
43 C 3-304.12 (C): During pauses in FOOD preparation or dispensing, FOOD preparation and dispensing UTENSILS shall be stored: (C) On a clean portion of the FOOD preparation table or cooking EQUIPMENT only if the in-use UTENSIL and the FOOD- CONTACT surface of the FOOD preparation table or cooking EQUIPMENT are cleaned and SANITIZED at a frequency specified under §§ 4-602.11 and 4-702.11.
violation: a knife was found stored in the crevice between the reach-in cooler and the adjacent warming table. the space between the two units are unclean. corrective action taken: the knife was cleaned and stored on a clean surface. COS
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
violation: observed the following equipment to be unclean: (1) grey storage shelves near cook line, (2) pizza prep table, and (3) the fan at cook line. corrective action required: clean and maintain equipment by the next routine inspection.
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
violation: the floor area below cooking and holding equipment at the main cook line is unclean. corrective action required: clean and maintain floors by the next routine inspection.
Inspection Comments   THE INSPECTION ALSO WAS REVIEWED HERSCHER RESTAURANT AND PUB'S PARTNERSHIP WITH HERSCHER MEALS ON WHEELS TO DELIVER MEALS.

HERSCHER RESTAURANT AND PUB COOKS THE MEALS AND HERSCHER MEALS ON WHEELS DELIVER THE MEALS TO RESIDENTS OF HERSCHER.

NO CHANGES HAVE OCCURRED REGARDING THEIR PARTNERSHIP.
HACCP Topic: PROPER REHEATING PROCEDURE: REHEAT PREVIOUSLY COOLED FOOD ITEMS TO 165F AND ONLY REHEAT ONE TIME.
 

Person In Charge

  ERDOGAN KURAP 		 

Date:

  10/06/2023
 

Inspector

  Alan Hatia 		 

Follow-up:  Yes   No   Follow-up Date:

10/16/2023